Convenience store beverage refrigerated display cabinet power consumption reasons
By Shenzhen Topwon Group Co.,Ltd
May 27, 2025
Large and small convenience stores are almost equipped with beverage refrigerated display cabinets, summer is also the store’s power consumption, then today to explain the reasons that lead to an increase in power consumption of beverage cabinets. Convenience store beverage cabinet power consumption is reflected in the following points.
Room temperature can not exceed the standard
Indoor temperature to a certain extent back to affect the refrigeration effect of the convenience store beverage cabinet. Temperature changes in large places will also increase the failure rate of accessories. Glass door display cabinets are prone to fogging the outer frame, affecting the refrigeration effect.
Maintain the stability of the ambient temperature
Should try to maintain the stability of the ambient temperature in the store, reduce the workload of the compressor. The ambient temperature has a direct impact on the power consumption of the refrigerator. Higher ambient temperatures will make the freezer cooling slower, the slow decline in temperature inside the box will lead to longer start-up time, increased power consumption.
Take data analysis
Take the ordinary freezer experimental data analysis, when the ambient temperature reaches 32 ℃. Power consumption is about twice as much as 25 ℃, 30 ℃ power consumption is 25 ℃ 1.6 ~ 1.8 times.
Far away from the heat source
Therefore, the cooler should be placed as far away from the heat source as possible, in a ventilated and shady place. Therefore, you should try to place the beverage cabinet on the backlit side and add shading equipment without affecting the business of the convenience store.
02.Setting a reasonable temperature
Each freezer has a thermostat to adjust the temperature inside the refrigerator by adjusting the gear. The higher the thermostat gear, the lower the temperature inside the freezer.
The colder the temperature, the harder it is to cool down
After the freezer reaches -18 ℃, every decline 1 ℃ is difficult, the colder the more difficult to decline, but the lowest temperature of continuous operation can reach -24 ℃ or less.
Effect of temperature difference between indoor and outdoor
At this time the same will also be due to the temperature difference between the inside and outside of the large, cold loss of more than a very long time to start or even do not stop. This thermostat is only for home refrigerators, and as a commercial freezer manufacturers, convenience store freezers leading brand of Andeli freezers using the thermostat, are accurate microcomputer control cabinet and display cabinet temperature.
Smaller error
The error is smaller, the cabinet temperature at a glance. Convenience store series of freezers are set at the factory for the 3-degree shutdown, 8-degree power on, but there is certainly a difference in the middle of the temperature, the weather is hot, the temperature will sometimes rise to 11-12 degrees, this phenomenon is also normal.
Do not repeatedly open and close the beverage cabinet
Repeatedly start and stop will affect the life of the beverage cabinet, repeated start and stop in the process will also increase the compressor workload, greatly increasing the power consumption. The use of beverage cabinets in not completely need to close the beverage cabinet, try not to close the convenience store beverage cabinet, in order to ensure energy saving can also be in accordance with the manufacturer’s instructions for the operation of the temperature.
Open the door as few times as possible.
Open the door of the beverage cabinet can feel the cold air to run out, and cold air run off will inevitably cause the temperature inside the cooler to rise, it will cause the thermostat is slow to reach the temperature of the shutdown and lead to the compressor to work for a long time, increasing power consumption.
In short, the above is the reason why the beverage cabinet power consumption, saving electricity, not only for the enterprise cost savings, but also environmental awareness. Therefore, in many stores, supermarkets, convenience stores, a large number of sales of beverages are not all placed in the beverage cooler, refrigerator inside, but on the corrugated paper beverage display rack. Only a very small number of cold beverage cabinets will be left as retail and offered to customers. It is customary for people to choose their favorite beverages from the corrugated paper beverage display racks, and then purchase them in bulk to go home and enjoy them in the refrigerator or freezer.